Detroit 60 series fault codes list.

Series 60 DDEC V Troubleshooting - Section 73.4 Troubleshooting Flash Code 81, PID 98/FMI 3; Series 60 DDEC V Troubleshooting - Section 73.5 Troubleshooting Flash Code 81, PID 173/FMI 3; Series 60 DDEC V Troubleshooting - Section 74 Flash Code 82 - Oil Level or Exhaust Temp Circuit Failed Low; Series 60 DDEC V Troubleshooting ...

Detroit 60 series fault codes list. Things To Know About Detroit 60 series fault codes list.

1. 1. 1. 1. ATTENTION. The information in this document is accurate as of April 2004 and is subject to change without notice. This manual is to be used in conjunction with the DDEC III/IV Single ECM Troubleshooting Guide and the DDEC V Single ECM Troubleshooting Guide. Series 60®, Detroit Diesel®, DDC®, DDEC® and the spinning arrows design ...could get a complete list of fault codes for my Detroit 60 Series 2009 Cascadia I couldn t find anything here and when I searched''DETROIT DIESEL 60 EGR SERIES TECHNICIAN MANUAL Pdf Download www.scraper.realestate.com.kh 2 / 11. April 16th, 2018 - Detroit Diesel 60 EGR Series Technician Manual Engine Detroit ...2005 freight liner century sid code 60.4 Detroit 60 series where is this modulator located. 2005 century classic with - Answered by a verified Technician. ... How to trobleshoot a 2004 detroit engine 14L 60 series with a fault code 63 ,SID 58 FMI 4.without a computer scanner. ...Freightliner and Detroit Diesel are both owned by Daimler which is why most Freightliners have Detroit Diesel engines with OBD codes as below. Fault Codes for Freightliner HD Trucks with Detroit Series 60 Engines with DTEC II. To Read Codes: Use diagnostic data reader or short pin A to pin M. The latter method will flash codes at the CEL. Codes ...To avoid injury from electrical shock, use care when connecting battery cables. The magnetic switch studs are at battery voltage. 7. Turn the ignition ON (key ON, engine OFF). 8. Measure the voltage between pins 11, 12, 14, 15, 18 and ground of the 21-pin ACM connector, harness side. Is the voltage measurement on pins 11, 12, 14, 15, and 18 ...

Series 60 DDEC VI Troubleshooting; Posted on June 14, 2019 March 13, 2024. ... If code is still active, call Detroit Diesel Technical Service. Series 50G and 60G Troubleshooting Guide - 6SE482: Generated on 10-13-2008: Posted in Series 50G & 60G Troubleshooting, SIDS. SIDS List of Contents.

60 Series Engine 14 L. Troubleshooting. The chart below shows the most common questions asked by owners of Detroit Diesel® Series 60 14 Ltr engines when trying to troubleshoot why their engines underperform. It categorizes areas of possible malfunction, likely cause and recommended action to bring your new, rebuilt or used Detroit Diesel ...

If any codes except code s 21/1 are logged, refer to "18.3 First Step for Diagnosing a Fault Within the DDEC System". Series 60 DDEC V Troubleshooting Guide - 6SE570 Generated on 10-13-20082. check ECM fuse, or fuses inside battery box and or power wires to the ECM. 3. pull flash codes, if no codes go to step 4. 4. check for fuel in tank, were filters changed recently, air in system, did someone not reopen fuel line valve to head, start with ether. 5. check fuel pressure valve behind head.On request. MTU Fault Codes. A DGC-2020 connected to a genset equipped with an MTU engine ECU tracks and displays the active. fault codes issued by the MTU engine ECU. Active MTU fault codes can be viewed through. BESTCOMSPlus by using the Metering Explorer to expand the MTU tree or through the front panel.If fault code s 146/1 is still active, contact the Detroit Diesel Customer Support Center at 313-592-5800. Section 4.3.2.3 146/2 — Erratic Data. Perform the following steps to resolve erratic EGR data:‪ Check active codes. If fault codes s 146/2 and s 146/0 are active at the same time, refer to "4.3.2.1 146/0 — EGR Temperature above …3. Clear codes with DDDL 7.0 or latest version. 4. Start and bring engine up to operating temperature (over 140°F/60°C). 5. Verify operation is satisfactory and no warning lamps illuminate. If warning lamps illuminate, troubleshoot the codes. If assistance is required, call the Detroit Diesel Customer Support Center at 313-592-5800.

1. Check for multiple codes. [a] If fault code 168/1 is active in addition to 3662/5, service 168/1 first. Refer to section 32.2. [b] If fault 3662/14 and 3664/14 are active in addition to 3663/14,. go to step 2. [c] If only fault code 3663/14 is active, go to step 9. 2. Turn the ignition OFF. 3. Disconnect the Rear Injector Harness 12-pin ...

Apr 16, 2014 · These codes are for your reference only. Detroit Diesel Series 60 Engines only; Please note: Codes 43, 44, and 45 are critical codes and if they are shown, the Stop Engine Light will come on which causes the engine protections to engage and your engine may shut down.

Series 60 DDEC V Troubleshooting - Section 77.2 Troubleshooting Flash Code 87, PID 73/FMI 4; Series 60 DDEC V Troubleshooting - Section 78 Flash Code 89 - AECL Sensor Fault or Fuel Inlet Restriction High; Series 60 DDEC V Troubleshooting - Section 78.1 Description of Flash Code 89, PID 111/FMI 12 & PID 95/FMI 0Series 60 DDEC V Troubleshooting - Section 74.1 Description of Flash Code 82; Series 60 DDEC V Troubleshooting - Section 74.2 Troubleshooting Flash Code 82, PID 411/FMI 4; Series 60 DDEC V Troubleshooting - Section 73.4 Troubleshooting Flash Code 81, PID 98/FMI 3; Series 60 DDEC V Troubleshooting - Section 73.5 Troubleshooting Flash ...SID 146 indicates that during engine operation the EGR system is experiencing. operation outside the normal range, resulting in one or more of the following fault codes. • EGR Temperature Above Normal (146/0) • EGR Temperature Below Normal (146/1) • Bad Component (146/12) • EGR – Valve is Not Responding (146/7) DDEC IV EGR DESCRIPTIONS. To read codes, use the Detroit Diesel Diagnostic Link (DDDL). The DDDL will display active and inactive fault codes which are listed in Table 4-1. Yellow= Sensor. Oct 7, 2020 · 2. Check for multiple codes. [a] If other faults are active in addition to fault 111/1, troubleshoot the other faults first. [b] If only fault 111/1 is active, go to step 3. 3. Check the coolant level in the reservoir. See Figure 30-1. [a] If the coolant level in the reservoir is not within limit, refer to section 30.1.2. Detroit Diesel Series 60 Engines only; Please note: Codes 43, 44, and 45 are critical codes and if they are shown, the Stop Engine Light will come on which causes the engine protections to engage and your engine may shut down. ... des-for-detroit-diesel-series-60-fault-codes/[/TD] [/TR] [/TABLE] TruckerLife1, Apr 16, 2014 ...Wanderlodge Owners Group - Powered by vBulletin

About Press Copyright Contact us Creators Advertise Developers Terms Privacy Policy & Safety How YouTube works Test new features NFL Sunday Ticket Press Copyright ...1997 Detroit Series 60 , getting a code "auxiliary output device #3" voltage above normal or shorted high, Number SS1,mode 3 what to check … read more. 2004 Detroit series 60 EGR engine. Detroit 06R0763710 Engine. 2004 Detroit series 60 EGR engine. Detroit 06R0763710Engine quit running.2. Check for multiple codes. [a] If codes 1636/3, 2629/3 and 412/3 are active at the same time, go to step 3. [b] If only fault 412/3 is active, disconnect the Intake Air Temperature Sensor and go to step 5. 3. Disconnect the Intake Air Temperature Sensor. 4. Measure the voltage between pin 1 of the Intake Air Temperature Sensor and ground.Series 60 DDEC V Troubleshooting - Section 74.1 Description of Flash Code 82; Series 60 DDEC V Troubleshooting - Section 74.2 Troubleshooting Flash Code 82, PID 411/FMI 4; Series 60 DDEC V Troubleshooting - Section 73.4 Troubleshooting Flash Code 81, PID 98/FMI 3; Series 60 DDEC V Troubleshooting - Section 73.5 Troubleshooting Flash ...People tend to have one of three beliefs about the meaning of work and which category you fall into largely depends on your parents, according to new research from the University o...Series 50 - Section 2.45 Fuel Shutoff Valves for the Series 50G Engine Prior to 1998; Series 50 - Section 2.46 Hose, Fitting, and Filter for the Series 50G Engine; Series 50 - Section 2.43 Venting and Leak Checking Procedures for a Natural Gas Engine (Low Pressure System) Series 50 - Section 2.44 Compuvalve for the Series 50G Engine

Series 60 DDEC V Troubleshooting – Section 75.1 Description of Flash Code 83; Series 60 DDEC V Troubleshooting – Section 75.2 Troubleshooting Flash Code 83, PID 411/FMI 0; Series 60 DDEC V Troubleshooting – Section 74.3 Troubleshooting Flash Code 82, PID 412/FMI 4; Series 60 DDEC V Troubleshooting – Section 74.4 Troubleshooting Flash ...Verify repair. 3 SPN 4077/FMI 4 - EPA07 - EPA10 - GHG14. Doser Fuel Line Pressure Sensor Circuit Failed Low. Table 2. SPN 4077/FMI 4. Description. This fault code sets when the Motor Control Module (MCM) detects that the Hydrocarbon (HC) Doser Fuel Line Pressure (FLP) Sensor Circuit is failed low. Monitored Parameter.

If the FMI is 0, 1, or 7, call the Detroit Diesel Customer Support Center (313-592-5800). ... Flash Code List of Contents. Series 60 DDEC V Troubleshooting - Section 78.2 Troubleshooting Flash Code 89, PID 111/12 ... Section 78 Flash Code 89 - AECL Sensor Fault or Fuel Inlet Restriction High;The code is typically a EGR High Flow.‪ ... obtain DDDL log file of failure and contact the Detroit Diesel Customer Support Center (313-592-5800) for further instruction. ... Section 128 SPN 4077 Fuel Line Pressure Sensor Circuit Fault; Series 60 DDEC VI Troubleshooting - Section 128.1 SPN 4077/FMI 3, 4 or 14;Section 01: ENGINE 2. DETROIT DIESEL SERIES 60 ENGINE system has a chassis-mounted control unit for vehicle engine management, the Common The DDC series 60 engine is a 6-cylinder, four- Powertrain Controller (CPC). ... ENGINE PID/SID FLASH PID/SID CODE FAULT DESCRIPTION 1334 Fan Stage 1 Circuit Failed Open 1242 Injector Cylinder #1 Needle ...Oct 11, 2020 · 3. Clear codes with DDDL 7.0 or latest version. 4. Start and bring engine up to operating temperature (over 140°F/60°C). 5. Verify operation is satisfactory and no warning lamps illuminate. If warning lamps illuminate, troubleshoot the codes. If assistance is required, call the Detroit Diesel Customer Support Center at 313–592–5800. I am seeing fault codes ecu 128 and numbers a 545 137 on my dash. Of my 2006 Freightliner Columbia 60 series 14L Detroit. Anyone know what's going on? Truckin2Eat, Jul 27, 2016. Truckin2Eat, Jul 27, 2016 #1. Trucking Jobs in 30 seconds. Every month 400 people find a job with the help of TruckersReport.I have a 2001 Freightliner FLD 120 Detroit 60 series I’m getting fault codes 46 54 34 62. 2001 Freightliner FLD 120. I - Answered by a verified Technician. ... I took a 60 series Detroit out of 2003 Freightliner Columbia and put it in 1999 Freightliner FLD. It will crank along as I'm spraying ether .But goes dead when I stop spraying. Page 85: 2-Groove Powerband. 200 lbs (890 N), then run the engine proper running tension for the belt, for 10 minutes at 1200 rpm. Stop the current Series 60 engines use an auto engine and allow a 10 – 15 minute belt tensioner, which requires no cool down period.

Detroit Diesel 60 and 40 Series Service Manuals. Detroit Diesel DD13 and DD15 Service Manual. 13 – The coolant level sensor is defective. Wires or connectors. 14 – The coolant level sensor is defective. Wires or connectors. 14 – The oil temperature sensor, wires or connectors are faulty.

Series 60 DDEC VI Troubleshooting - Section 128 SPN 4077 Fuel Line Pressure Sensor Circuit Fault; Series 60 DDEC VI Troubleshooting - Section 128.1 SPN 4077/FMI 3, 4 or 14; Series 60 DDEC VI Troubleshooting - Section 127.1 SPN 3720/FMI 15 or 16; Series 60 DDEC VI Troubleshooting - Section 126 SPN 3798 - Proportional Valve Bank 2 Circuit

MID 190 Air Conditioner Subsystem Fault Codes. 1 Freon Level REFRGNT CHRG REFRIG Pres 2 Humidity Levels in Freon REFRIG MOISTR REFRIG Moistr 3 Non-Condensed Gas in Freon GAS IN REFRIGN Gas In REFRIGN 4 Solenoid, Freon Control Flow RFRG FLOW CTRL RFRG Flow Ctrl 5 Freon Low Pressure Sensor LOW PRS SWITCH Low Pres SW 6 Chain Compressor Management ... Series 60 DDEC V Troubleshooting - Section 78 Flash Code 89 - AECL Sensor Fault or Fuel Inlet Restriction High Series 60 DDEC V Troubleshooting - Section 78.1 Description of Flash Code 89, PID 111/FMI 12 & PID 95/FMI 0Detroit Diesel s60 Sensors [PDF] 336.9kb. Download. Detroit Diesel 50-60 Series, 53, 71, 92 AND 149 Series Engines - Replacement Parts [PDF] 1.7Mb. Download. Detroit Diesel 60 EGR Series Technician Manual [PDF] 2.9Mb.Jun 10, 2019 · Series 60 DDEC VI Troubleshooting – Section 127.1 SPN 3720/FMI 15 or 16; Series 60 DDEC VI Troubleshooting – Section 128 SPN 4077 Fuel Line Pressure Sensor Circuit Fault; Series 60 DDEC VI Troubleshooting – Section 128.1 SPN 4077/FMI 3, 4 or 14; Series 60 DDEC VI Troubleshooting – Section 126 SPN 3798 – Proportional Valve Bank 2 Circuit [a] If fault code 146 02 is no longer active, repair open circuit in wire between pin 11 of the 55-pin connector and pin 3 of the EGR valve and check for active fault codes. If fault code 146 02 is no longer active, erase fault code memory. [b] If fault code 146 02 is still active, go to step 5. 5. Check the resistance between pin 50 of the 55 ...Discover the best SEO firm in Detroit. Browse our rankings to partner with award-winning experts that will bring your vision to life. Development Most Popular Emerging Tech Develop...1. Check for multiple codes. [a] If fault code 168/1 is active in addition to other codes, service 168/1 first. Refer to section 32.2. [b] If fault 652/14 and 653/14 are active in addition to 651/14, go to step 2. [c] If only fault code 651/14 is active, go to step 10. 2. Turn the ignition OFF. 3. Disconnect the Front Injector Harness 12–pin ...Flash Code readings on a Detroit Diesel 60 series eng TruckFaultCodes.com Introduction FIX ANY CUMMINS FAULT CODE STEP BY STEP (VIDEO 1 OF 9) Detroit Diesel Electronic Control (DDEC) System IV, V, VI \u0026 10 Codes ECM Detroit 60 Series how to fix the problem.SPN List of Contents. Series 60 DDEC VI Troubleshooting – Section 131.2 SPN 4259/FMI 4; Series 60 DDEC VI Troubleshooting – Section 130.2 SPN 4258/FMI 4; Series 60 DDEC VI Troubleshooting – Section 131 SPN 4259 – Injector #4, 5, or 6 Spill Control Valve Not Operating Normally; Series 60 DDEC VI Troubleshooting – Section 131.1 SPN 4259 ...Detroit Diesel engine DD15, Series-40,-50,-53,-60,-71,-92, MBE 900, MBE 4000, V-71 - in this category, you can find and free download workshop repair manuals, service manuals, electrical wiring diagrams, fault codes for Detroit Diesel engines. ... Detroit Diesel Engines Fault Codes List (DTC) See also: Detroit Diesel Engines PDF Service Repair ...

The repair for SPN 3597 FMI 4 EPA 10 is as follows: 1. Disconnect the Diesel Exhaust Fluid (DEF) pump, Pressure Limiting Unit (PLU), diffuser heater, and the DEF injection valve (disregard the additional faults set with components disconnected). 2. Inspect the above component harness connectors for bent, spread, or corroded pins.4. Read active codes. 5. If active codes 100/3 or 4 or 19/3 or 4, were logged, proceed with the following: →If active codes 100/4 or 19/4 and any other codes were logged, refer to "Check for +5 Volts". →If codes 100/3 or 19/3, and any other codes except 100/4 or 19/4 were logged, refer to "Check Oil Pressure Sensor Connectors". 6.Detroit’s economic decay has been closely watched. It’s a gripping narrative. The city stood for decades as a pillar of industry, harnessing the skilled, creative labor of its loca...Instagram:https://instagram. bath and body works career benefitslizakovalenkocraftsman 46 mower deck belt lengthhanging out to the point of torpor crossword clue down.Fault Codes for Detroit Diesel Series 50/60 Engines ...DETROIT DIESEL Engine Fault Codes list DTC Code Description DDEC V Circuit 11 P 187 4 Chain PTO. Short circuit in the power 11 P 187 7 control system PTO wrong answers 12 P 187 3 Chain PTO. Short circuit in the ground 13 P 111 4-level1. Check for multiple codes. [a] If fault code 168/1 is active in addition to other codes, service 168/1 first. Refer to section 32.2. [b] If fault 652/14 and 653/14 are active in addition to 651/14, go to step 2. [c] If only fault code 651/14 is active, go to step 10. 2. Turn the ignition OFF. 3. Disconnect the Front Injector Harness 12–pin ... somara theodore leaving todaydevon and big freedia Welcome to JA! ecu 128 fault 411. pid 411-Recirculated Engine Exhaust Gas Differential Pressure. But that is only part of the fault code ! You should have an FMI number! (fault mode indicator) This number tells us what exactly is wrong with the recirculated engine exhaust gas differential pressure! Here is a PDf file for the rest of the codes.84. 6.77 KB. Download. (09-07-2015, 06:38 PM)Nitrous383 Wrote: Flash code 46 is a battery voltage issue. Usually it is a poor connection in the ECM powers or grounds. Check/clean all connections from the ECM to the batteries. I am aware the 46 is a battery voltage issue. I checked the power harness and saw no problems. 8446401861 31 flash code 31 - engine brake fault code 31.1 description of flash code 31 ..... 31-3 31.2 sae j1587 equivalent code for flash code 31 ..... 31-3 31.3 troubleshooting flash code 31 ..... 31-4 32 flash code 32 - cel / sel faultPage 41 SERIES 60 EGR TECHNICIAN'S GUIDE DDEC IV EGR DESCRIPTIONS To read codes, use the Detroit Diesel Diagnostic Link (DDDL). The DDDL will display active and inactive fault codes which are listed in Table 4-1. ... Page 75 SERIES 60 EGR TECHNICIAN'S GUIDE Fault Codes Window All information subject to change without notice. (Rev. April 2004 ...